Skip to main content

Significant reduction in bacterial shedding and improvement in milk production in dairy farms after the use of a new inactivated paratuberculosis vaccine in a field trial

Abstract

Background

Paratuberculosis vaccination has been in use in some regions for many decades, but results have not been widely spread. A new Mycobacterium avium subsp. paratuberculosis (MAP) killed vaccine was studied in relationship with its effects on fecal shedding and milk production in four farms while other two were kept as controls submitted to a test and cull scheme.

Findings

Fecal detection (n = 1829) and milking records (n = 2413) have been analyzed after two (5 herds) and four (1 herd) years of the beginning of the intervention. Shedder prevalence was reduced by 100% in three of the four vaccinated farms, 68% in the total of vaccinated animals and 46% in the two control farms. Total amount of MAP shed was reduced 77% in the vaccinated farms and 94% in the control farms. Overall milk production increased up to 3.9% after vaccination, while there was no significant difference in production after intervention in the non-vaccinated farms.

Conclusion

MAP shedding reduction can be quickly accomplished both by vaccination and by testing and culling. However, vaccination appears to be a less expensive and more sustainable strategy since it required one single intervention and was also associated with an increase in milk production.

Background

Paratuberculosis or Johne's disease eradication programs based on the detection and culling of infected animals (testing and culling, T&C) have been relatively unsuccessful due to the low sensitivity of diagnostic tests and unending expenses for detection of infection in individual animals. Even though vaccination has been successfully used for over 30 years in the US and in the UK as well as in other countries, scientific reports on its efficacy are old and scarce in spite of having shown to yield higher benefit/cost ratios than T&C strategies [1, 2].

Near eradication of bovine tuberculosis in the Basque Country, as well as high prevalence of clinical cases of paratuberculosis in some farms, led the local Animal Health Authorities to support a vaccination trial in farms with a history of heavy clinical incidence. This trial was implemented as a field assay to test the efficacy of a new paratuberculosis vaccine specifically designed for use in cattle and that is based in whole cell heat-killed MAP (Silirum®, CZ Veterinaria, S.A., Porriño, Spain) in an oil adjuvant. The objective of the present report is to evaluate its performance on MAP fecal excretion as an indicator of epidemiologic efficacy, to assess any possible therapeutic effects of vaccination and to estimate direct benefits in milk production that could facilitate the spread of this control strategy by encouraging farmers to use of the vaccination as a control strategy at their own expense. The follow up is scheduled to last five years in each herd, and therefore the results presented here are a preliminary assessment.

Findings

MAP detection in feces

Fecal shedding frequencies by PCR and by isolation before intervention and at each annual sampling are shown in table 1 and figure 1. Significant reduction in fecal shedding across herds ranged from 71% to 90% with PCR, and from 75% to 100% with culture. Globally, vaccination seemed to induce greater reductions (86% and 68% for PCR and culture, respectively) than T&C (60% and 46% for PCR and culture, respectively. This relationship seemed to be inverted when the amounts of shedding were compared (Figure 2). For this variable, T&C (4,702,381 CFU/day/100 cows to 292,308 CFU/day/100 cows) yielded a reduction of 94% versus a 76% associated to vaccination (1,925,926 CFU/day/100 cows to 452,675 CFU/day/100 cows) (Figure 2).

Figure 1
figure 1

Prevalence of cows excreting MAP in their feces at each fecal control as measured by isolation and by IS900 PCR. AI0: Before intervention, PI1: First post-intervention control; PI2: Second control post-intervention. Culture T&C: Results of fecal culture in the two herds without vaccination. Culture VAC: Results of fecal culture in the four herds with vaccination. PCR T&C: Fecal IS900 PCR positive results in the two herds without vaccination. PCR VAC: Fecal IS900 PCR positive results in the four herds with vaccination.

Figure 2
figure 2

Evolution of estimated amount of daily bacterial shedding per cow according to the strategy. Although in the first years T&C appears to be substantially more efficient, vaccination still seems to reduce shedding by three fourths. AI0: before intervention, PI1: First post-intervention control; PI2: Second control post-intervention; Reduction: Percent of reduction in the estimated amount of bacteria shed from the initial to the last control. Notice that this approach shows a slower reduction with vaccination than when only frequency of shedders is considered.

Table 1 Frequency of fecal shedding at different time point as detected by IS900 PCR and isolation and rate of reduction between pre-intervention sampling and last control.

Milk production

A total of 2762 lactations, of which 2413 were complete 305-day standard lactations (SL), were used for the analysis of variance. The overall model including parity, strategy (testing and culling or vaccination) and intervention (ante- and post-intervention) and all their interactions was highly significant on standard and real lactation milk production, days of lactation and average daily production (ADP). Only the models for SL and ADP as dependent variables had an R2 value greater than 0.10 and thus only these were retained for the final analysis (Table 2). The SL model, with an R2 value of 0.1792, showed that the strongest effects were those of parity and strategy (p < 0.0001) and the interaction between strategy and intervention (p = 0.0259). Upon marginal means comparison, it appeared that there was no significant difference between ante- and post-intervention SL in the T&C herds (-186.87 kg; p = 0.2318), while there was a difference of 257.13 kg in the vaccinated ones (p = 0.0376) (Table 2). No other effect or interaction had a p value below 0.10. Regarding the ADP, the only significant effects were again those of the strategy and parity interaction between strategy and ante- or post-intervention periods (p = 0.0035). The differences between ante- and post-intervention ADP were -0.54 kg (p = 0.2079) and 1.08 kg (p = 0.0020) respectively for T&C and vaccination. The latter accounted for a difference of 329.4 kg in SL. The cows in the T&C strategy showed higher variability in the differences in production, with a significant decrease (p = 0.0336 SL; p = 0.0030 ADP) for the second calving. The vaccinated herds showed always a positive balance between ante- and post-intervention milking records, with significant increases in production for first (p = 0.0759, N.S. SL; p = 0.0247 ADP) and third (p = 0.0422; p = 0.2627, N.S.) calving.

Table 2 Milk production

Discussion

The results presented here show that both T&C and vaccination had a significant effect on the bacteriologic variables relevant to the epidemiology of paratuberculosis. Even though the timing and magnitude of the reductions were not the same in all the farms, the overall effect in terms of frequency of shedders and of estimated amount of bacteria excreted were greatly reduced both by T&C and by vaccination. It is somewhat surprising that so good results were observed in such a short period of time. These observations are in agreement with most works on paratuberculosis vaccination [3–15].

Regarding milk production, in this study, vaccination performed better than T&C. This is in agreement with reports on paratuberculosis related milk losses [1, 16] even though in a study vaccination had a slight negative effect on non-infected animals that was compensated by the large effects on milk production of advanced cases of paratuberculosis[9].

An important issue in this study is that the controls have not been taken from matched individuals in the same herd, but that each farm has been on one strategy. This was a difficult decision taken at the beginning of the study in order to avoid the influence of treatment on one group affecting the other in the long period of follow up imposed by the slow infection characteristic of paratuberculosis. This, in addition to the need of farmers of an immediate and readily visible solution to their paratuberculosis problem, as well as the management difficulties of herds with mixed strategies, made it more advisable to use a before-/after- comparison strategy in spite of its limitations in order to attribute the effects solely to vaccination.

Our results, obtained in over 80% of cases from animals vaccinated after at least three months of life in its infected farm, show that there might be therapeutic effects related to the pathogenesis-modifying effects of vaccination that were already observed twenty years go by Benedictus et al[5]. This implies that vaccination could not only provide an immediate relief to farms affected by a heavy incidence of paratuberculosis, but would allow to foresee a completely new strategy for treatment of human IBD if its paratuberculosis etiology is demonstrated and accepted by the gastroenterological community.

In conclusion, the results presented here show that similar levels of paratuberculosis control can be achieved in a short period of time both by T&C and by vaccinating with the new killed vaccine, at least in some farms. If eradication is ruled out as the failure of long term strategies shows[17, 18], vaccination stands out as the most economically efficient strategy at similar or better epidemiologic performances with T&C[2]. Since it involves protecting animals instead of killing the infected ones, vaccination is also a more sustainable strategy for paratuberculosis control than T&C.

Materials and methods

Farm selection

Six Holstein Friesian herds of the Basque Country with a history of clinical paratuberculosis whose owners were willing to collaborate were selected. The annual incidence of paratuberculosis clinical cases in these herds ranged from 2 to 10%. They were officially free of bovine tuberculosis for, at least, the last 5 years as determined by regular intradermal tuberculin test. The first herd (END) to enter the study was vaccinated in January 2003 and the other three (AGE, SAG, SAL) were vaccinated in March 2006. Two herds of similar characteristics were kept as controls submitted to a test and cull strategy without vaccinating any animals. This strategy consisted in recommending the farmers to cull animals with an indirect ELISA or fecal PCR positive result. The two non-vaccinated herds were sampled for the first time in May, 2006 and this date was set as the threshold for intervention temporal comparisons.

Vaccine administration

One ml of the Silirum® MAP vaccine (CZ Veterinaria, S.A., Porriño, Spain), was administered subcutaneously into the dewlap of all animals of all ages present in the farm at the moment of joining the trial, and then to all the new 1-2 month old replacer female calves. This resulted in that over 80% of the post-vaccination observations were from animals vaccinated when older than 3 months. Each dose contained 2.5 mg of heat-killed 316F MAP strain plus an oil adjuvant and thiomersal as preservative.

Experimental vaccination was carried out according to the Spanish legislation. It was authorized by the competent local Animal Health and Animal Experimentation authority (Animal Health Service of the Diputación Foral de Gipuzkoa and Diputación Foral de Bizkaia, respectively for the vaccinated and non-vaccinated herds), the Spanish drug registration authority (Agencia Española de Medicamentos y Productos Sanitarios as AEM n° 107/ECV) and well as by the central Animal Health authority (Spanish Ministry of Agriculture, Fisheries and Food, currently Ministerio de Medio Ambiente y Medio Rural y Marino).

Fecal sampling

Feces were collected from the rectum of the cows older than 24 months on the ante-intervention (AI0) control at the time of reading the intradermal test and at yearly intervals afterwards. They were stored at 4°C and processed within 48 h of arrival to the laboratory for DNA isolation and for fecal culture.

Amplification of MAP DNA from fecal samples

Isolation of MAP DNA from fecal samples was performed using the Adiapure MAP DNA extraction and purification kit (Adiagene, Saint Brieuc, France). Two μl of DNA solution were tested with a commercial qualitative Real-Time PCR kit based on the amplification of a segment of the MAP IS900 sequence (Adiagene, Saint Brieuc, France) according to the manufacturer instructions. For each set of reactions, positive (MAP DNA from an ATCC19698 culture) and negative (no DNA) controls were included. The amplifications were performed in an ABI Prism type 7000 (Applied Biosystems, Foster City, CA, US) thermal cycler under the following conditions: 2 min at 50°C, 10 min at 95°C and 45 cycles of 15 s at 95°C and 60 s at 60°C. Results were read as positive when the reaction showed a typical amplification curve and a Ct value below 40.

Detection of MAP by fecal culture

Culture of MAP from fecal samples was performed as previously described [19] on home-made Herrold's Egg Yolk medium (HEYM) and in Löwenstein-Jensen medium (L-J) (Difco, Detroit, Michigan, US), both supplemented with mycobactin J (Allied Monitor, Fayette, Missouri, US)[20]. Tubes were observed every 4 weeks and considered negative if after 20 weeks no bacterial growth was observed. Samples were considered positive if 1 or more colonies forming units (CFU) were morphologically identified as MAP in 1 or more culture tubes. Animals were classified as low shedders (< 10 CFU; estimated average 2 CFU/tube), medium shedders (10 to 50 CFU; estimated average 20 CFU/tube) and heavy shedders (> 50 CFU; estimated average 200 CFU/tube). Colony identity was confirmed by PCR amplification of the IS900 MAP insertion sequence, as described above.

Milk production

Records of individual cow production kept by the Basque Federation of Friesian Breeders (EFRIFE) were kindly provided by M. Eugenia Amenabar. They included date of birth, date of calving, monthly milk production record, days of lactation and real and 305 days-standard milk production per lactation. The records corresponding to years 2000 to 2007 were used representing up to 5 years before and after intervention.

Statistical analysis

The frequency of shedders before and after intervention according the herd strategy (vaccination or test and cull) were compared using the SAS statistical package Fisher exact test of the FREQ procedure (SAS Institute Inc., Cary, NC 27513, USA). A quantitative estimate of overall bacterial contamination by fecal shedding was made according to the quantitative equivalences defined above for each level of colony counts. After natural logarithm transformation the results were submitted to analysis of variance and least square means comparison with the GLM procedure taking as independent variables the type of intervention, the time after intervention and their interaction.

For milk production, the SAS GLM procedure was used for analysis of variance and least square mean comparison of real lactation, days of lactation, standard 305 days lactation kg of milk (SL) and average daily production (kg of milk divided by actual number of days in lactation, ADP) as dependent variables. In this model, strategy, intervention (ante- and post-intervention date) and parity were used as independent variables. All the least square means where compared using the Student's t test with the Tukey adjustment for multiple pair-wise comparisons.

Reductions and increases were calculated as the quotient of the difference between the compared and the reference level mean or frequency to the reference level mean or frequency.

References

  1. Benedictus G, Dijkhuizen AA, Stelwagen J: Economic losses due to paratuberculosis in dairy cattle. Vet Rec. 1987, 121: 142-146.

    Article  CAS  PubMed  Google Scholar 

  2. Juste RA, Casal J: An economic and epidemiologic simulation of different control strategies for ovine paratuberculosis. Prev Vet Med. 1993, 15: 101-105. 10.1016/0167-5877(93)90106-4.

    Article  Google Scholar 

  3. Argenté G: Utilisation de la culture fecale dans un plan de prevention de la paratuberculose dans 500 tropeaux; Justifications techniques et economiques. Proc Int Coll PTBC II. Edited by: Thorel MF, Merkal RS, Thorel M, Merkal R. 1988, Maisons-Alfort. France. Laboratoire Central de Recherches Veterinaires, 30-35.

    Google Scholar 

  4. Argenté G: Efficiency of vaccination and other control measures estimated by fecal culturing in a regional program. Proc Int Coll PTBC III. Edited by: Chiodini R, Kreeger J. 1992, Providence, RI, USA. IAP, 495-503.

    Google Scholar 

  5. Benedictus G, Dinkla ETB, Wentink GH: Preliminary results of vaccination against paratuberculosis in adult dairy cattle. Proc Int Coll PTBC II. Edited by: Thorel M, Merkal R. 1988, Maisons-Alfort. France. Laboratoire Central de Recherches Veterinaires, 136-140.

    Google Scholar 

  6. Kalis CHJ, Van Schaik G, Dijkhuizen AA, Benedictus G: Economic significance of vaccination against paratuberculosis. Proc Int Coll PTBC IV. Edited by: Chiodini RJ, Collins MT, Bassey EOE. 1995, Rehoboth, MA, USA. IAP, 136-139.

    Google Scholar 

  7. Kalis CHJ, Benedictus G, van Weering HJ, Flamand F, Haagsma J: Experiences with the use of an experimental vaccine in the control of paratuberculosis in The Netherlands. Proc Int Coll PTBC III. Edited by: Chiodini R, Kreeger J. 1992, Providence, RI, USA. IAP, 484-494.

    Google Scholar 

  8. Hurley SS, Ewing E: Results of a field evaluation of a whole cell bacterin. Proc Int Coll PTBC I. Edited by: Merkal R. 1983, Ames, IA, USA. NADC, USDA, 244-248.

    Google Scholar 

  9. Van Schaik G, Kalis CHJ, Benedictus G, Dijkhuizen AA, Huirne RBM: Cost-benefit analysis of vaccination against paratuberculosis in dairy cattle. Vet Rec. 1996, 139: 624-627.

    CAS  PubMed  Google Scholar 

  10. Doyle TM: Vaccination against Johne's disease. Vet Rec. 1964, 76: 73-76.

    Google Scholar 

  11. Hore DE, McQueen DS, Mclean J: Infection of dairy cattle with Mycobacterium johnei in a partially vaccinated herd. Aust Vet J. 1971, 47: 421-423. 10.1111/j.1751-0813.1971.tb02169.x.

    Article  CAS  PubMed  Google Scholar 

  12. Körmendy B: The effect of vaccination on the prevalence of paratuberculosis in large dairy herds. Vet Microbiol. 1994, 41: 117-125. 10.1016/0378-1135(94)90141-4.

    Article  PubMed  Google Scholar 

  13. Wentink GH, Bongers JH, Zeeuwen AAPA, Jaartsveld FHJ: Incidence of Paratuberculosis after Vaccination against M. paratuberculosis in Two Infected Dairy Herds. J Vet Med B. 1994, 41: 517-522.

    Article  CAS  Google Scholar 

  14. Wilesmith JW: Johne's disease: A retrospective study of vaccinated herds in Great Britain. BVJ. 1982, 138: 321-331.

    CAS  PubMed  Google Scholar 

  15. Larsen AB, Moyle AI, Himes EM: Experimental vaccination of cattle against paratuberculosis (Johne's disease) with killed bacterial vaccines: A controlled field study. Am J Vet Res. 1978, 39: 65-69.

    CAS  PubMed  Google Scholar 

  16. Ott SL, Wells SJ, Wagner BA: Herd-level economic losses associated with Johne's disease on US dairy operations. Prev Vet Med. 1999, 40: 179-192. 10.1016/S0167-5877(99)00037-9.

    Article  CAS  PubMed  Google Scholar 

  17. Dinkla ETB: Eradication program for paratuberculosis in North-Netherlands since 1972. Proc Int Coll PTBC II. Edited by: Thorel M, Merkal R. 1988, Maisons-Alfort. France. Laboratoire Central de Recherches Veterinaires, 25-29.

    Google Scholar 

  18. Whitlock RH, Sweeney RW, Hutchinson LT, Van Buskirk M: Pennsylvania Johne's disease program (1973 to 1993): a review of the twenty year program. Proc Int Coll PTBC IV. Edited by: Chiodini RJ, Collins MT, Bassey EOE. 1995, Rehoboth, MA, USA. IAP, 102-110.

    Google Scholar 

  19. Garrido JM, Aduriz G, Juste RA, Geijo MV: Los métodos de diagnóstico de la paratuberculosis en el ganado vacuno. Paratuberculosis BovisMadrid. Luzan 5. Edited by: Juste RA. 2000, 49-61.

    Google Scholar 

  20. Sevilla I, Garrido JM, Geijo M, Juste RA: Pulsed-field gel electrophoresis profile homogeneity of Mycobacterium avium subsp. paratuberculosis isolates from cattle and heterogeneity of those from sheep and goats. BMC Microbiol. 2007, 7: 18-10.1186/1471-2180-7-18.

    Article  PubMed Central  PubMed  Google Scholar 

Download references

Acknowledgements

This study was funded by a grant from the (Instituto Nacional de Investigacion y Tecnologia Agraria y Alimentaria, INIA) (RTA2005-00147-00-00) and by CZ Veterinaria, S.A. Dr. Marta Alonso and Dr. Joseba Garrido salaries were partly covered by the INIA program for incorporation of PhD graduates to research institutions. We are especially indebted to Carlos Boix and Jose M. Plazaola from the Animal Health Service of the Diputacion Foral de Gipuzkoa for authorizing and supporting the use of the vaccine and in general providing the framework in which the vaccination trial could be set. We are also grateful to Iñaki Arrazola and Blanca Ocabo from the Animal Health Service of the Diputacion Foral de Bizkaia that have supported the follow-up of the non vaccinated herds. We express our thanks to Francisco J. Mendizabal, Juan R Urteaga, Isidro Aristi and Xabier Kaminos, veterinary practitioners that carried out the immunizations, performed the intradermal tests, helped taking samples and provided clinical information. We want to acknowledge M. Eugenia Amenabar, Secretary of the Basque Friesian Breeders Association for straightforward access to milking records and permission to use them. The authors thank particularly the farm owners for their lending animals, facilities, information and work for this study.

Author information

Authors and Affiliations

Authors

Corresponding author

Correspondence to Ramon A Juste.

Additional information

Competing interests

RAJ had expenses paid by a company for giving a conference, attending a meeting and making an expert report for registration of a vaccine against paratuberculosis two years ago. RAJ, MVG and JGA own a small participation of an equity that supports a small company that is a spin-off of NEIKER in a project for the development of an improved vaccine for paratuberculosis.

Authors' contributions

RAJ designed the experiment, performed the statistical analysis and wrote the final version of this report. JMG contributed to the experimental design and oversaw the farms follow up. MAH helped in the writing. EMO, MGE, PVA, ISE and JMG participated in the sampling and processing of the fecal samples. All the authors read the final version of this manuscript.

Authors’ original submitted files for images

Rights and permissions

This article is published under license to BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/2.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly cited.

Reprints and permissions

About this article

Cite this article

Juste, R.A., Alonso-Hearn, M., Molina, E. et al. Significant reduction in bacterial shedding and improvement in milk production in dairy farms after the use of a new inactivated paratuberculosis vaccine in a field trial. BMC Res Notes 2, 233 (2009). https://0-doi-org.brum.beds.ac.uk/10.1186/1756-0500-2-233

Download citation

  • Received:

  • Accepted:

  • Published:

  • DOI: https://0-doi-org.brum.beds.ac.uk/10.1186/1756-0500-2-233

Keywords